Search results

  1. UnityUSA

    Post Mount Spotlight 15+ Tahoe

    If there is a notch milled into the side of the shaft that the handle slides over, this is called a flat. If your light has a flat you will use one set of wedge and wedge screw. If it does not you will use a different set. With Flat: U-8384-P Wedge...
  2. UnityUSA

    Post Mount Spotlight 15+ Tahoe

    Links for wedge and wedge screw used to secure handle are below. For tightening the light there is a metal piece that connects the head of the light to the shaft of the light. On the bottom of this piece there are three screws. The one closest to the shaft controls swing of the shaft. Tightening...
  3. UnityUSA

    Beacon parts?

    Ring Assembly: https://www.unityusa.com/U-1291-a-Ring-Assembly-RV26-45-46_p_580.html Clear Dome: https://www.unityusa.com/1282-C-Clear-Dome-RV26-45-46_p_618.html
  4. UnityUSA

    Motor swap?

    Maybe. If they are the same vintage we used sameish motors for RV25 and RV46. We had different generations of motors throughout the life of the RV line and to my understanding those motors do not switch between each other, but the fit of the motor for RV25 and 46 built at the same time would...
  5. UnityUSA

    Wiring for a Unity RV-25

    This is a old parts sheet with 25 on it. Not sure how helpful it will be but it's the closest we have.
  6. UnityUSA

    Are these RV-25 Parts ?

    Didn't have a much time to do this so it's a little rough but hopefully gets the info across. Numbers correspond to attached picture 1. These are our motors but we had two version that looked the same so cannot tell for sure from picture. One was faster one was slower. If they are the faster...
  7. UnityUSA

    Wanted Wanted Unity RV26 OR RV46

    If you find one without a red dome, We still have red domes available: https://www.unityusa.com/1282-R-Red-Dome-RV264546_p_619.html
  8. UnityUSA

    Can you identify this Unity light?

    This is a model S6 AG Series Decklight. The part missing on top is for the name plate that would identify the model. This is an older version from the one we currently make but still very similar. We no longer carry red lamps. Also there should be a switch to turn the light on and off on the...
  9. UnityUSA

    RV-45 gear replacement issue

    The gear shaft is held in place by two snaps rings on the shaft that match into grooves on the shaft. Removing the snap rings would allow the shaft to be pulled out. I do not have a way to remove them, we don't have any disassembly instructions.
  10. UnityUSA

    RV-26 vs. RV-46 Flashes Per Minute

    3018 Gear/Shaft Kit is now online: http://www.unityusa.com/3018-Beacon-GearShaft-Replacement-Kit_p_3341.html
  11. UnityUSA

    RV-45 gear replacement issue

    3018 Gear/Shaft Kit is now online: http://www.unityusa.com/3018-Beacon-GearShaft-Replacement-Kit_p_3341.html
  12. UnityUSA

    RV-26 vs. RV-46 Flashes Per Minute

    That version doesn't have a trick, but gets noisy when the bronze gear 7684 wears out. Due to how it is assembled we used to sell the gear as part of a Gear/Shaft Replacement kit and couldn't sell it on its own. Based on our system it looks like we still have the parts but have not sold it in a...
  13. UnityUSA

    Unilite manual

    My understanding is that the light is old enough that back when it was first made it was decided the light was simple enough that a manual wasn't needed. Then it just never got one. Still isn't a manual on bill of materials.
  14. UnityUSA

    Unilite manual

    We do not have a manual for the Unilite. What information do you need? We may be able to help.
  15. UnityUSA

    RV-26 vs. RV-46 Flashes Per Minute

    Kinda, but depends on the version. If you could send a picture of it, we can take a look and offer suggestion.
  16. UnityUSA

    RV-26 vs. RV-46 Flashes Per Minute

    1294 is the geartrain for the motor. 2922 was motor for 25 and 26. 2923 was the motor for the 45 & 46.
  17. UnityUSA

    RV-26 vs. RV-46 Flashes Per Minute

    ^That. Combo of dwell time and have 4 lights would mean 4 directions are getting light at the same time as opposed to only two.
  18. UnityUSA

    RV-26 vs. RV-46 Flashes Per Minute

    Both lights are rated at around 100 flashes per minute to land within the 60-120 flash per minute SAE standard. Actual flashs per minute have varied over time with use of different motors throughout the life of the lights. To have the flashes match, the 26 has a faster motor than the 46 to...
  19. UnityUSA

    Post mount spotlight on 2017 Ford F-150 pickup

    When the automotive companies run the roof crush tests for spotlights, they are run with the hole, but without the spotlight in the hole or mounting hardware. If the vehicle does not pass the industry standard with the hole then a spotlight does not get installed. The reason the Crown Vic test...
  20. UnityUSA

    Post mount spotlight on 2017 Ford F-150 pickup

    Post mount spotlights do not impact the integrity of the roof. In tests run by automotive companies they found no drop in integrity and Ford in the case of the crown vic found that the vehicle was stronger with the light installed. Ford does not install spotlight on any Special Service Vehicles...
  21. UnityUSA

    Post mount spotlight on 2017 Ford F-150 pickup

    grondoline, We have had many customers install spotlights on current version of F-150 without any of the issues you mentioned. The light comes into the vehicle below the grab handle on both sides and does not impact the steering wheel. I have attached some photos of install. One shows passenger...
  22. UnityUSA

    Help with Unity cowl light

    Nolines, if you send me a PM with your name and order number and any other information relavent to the issue, I can look into it.
  23. UnityUSA

    Help with Unity cowl light

    Not a foolish question at all. Its a little tricky process. Instructions are attached.
  24. UnityUSA

    100 YEARS OLD!!!

  25. UnityUSA

    RV 26/46 Beacon Questions

    I would say no to the U-7682 lamp. We never made RV-26 with them so I tried putting one into a RV-26 and was unable to get the spring clip around, whereas had no problem with the U-4537-2 lamp. Someone else might be able to do it but I couldn't get it in. Even if the spring fit, there was a gap...
  26. UnityUSA

    RV 26/46 Beacon Questions

    They were made of steel and were stamped and trimmed. No exhaust pipes were harmed in the making of that part.
  27. UnityUSA

    RV 26/46 Beacon Questions

    Was also just given this: One additional note on spitfire - Clear Top Coat (U.V. Inhibitor ROHM & HAAS # LS123
  28. UnityUSA

    RV 26/46 Beacon Questions

    Sorry for the delay, took some time to locate the info since anything we still have was archived. Answers are below: Specs (RPM, amp ratings, etc.) on the old motor(s) – we pulled the drawing and it does not have the motor information it has the requirement for the 2 lamp unit to rotate 45 –...
  29. UnityUSA

    RV 26/46 Beacon Questions

    Just wanted to update, we did not forget about responding, just still work in progress. Sorry for the delay.
  30. UnityUSA

    RV 26/46 Beacon Questions

    Our resident beacon "expert" has been working on a response, but went on vacation this week. Wanted to let you know we are working on response but since it is not an active product it takes time to find information.

Forum Statistics

Threads
53,972
Messages
449,821
Members
19,104
Latest member
airflores

About Us

  • Since 1997, eLightbars has been the premier venue for all things emergency warning equipment. Discussions, classified listings, pictures, videos, chat, & more! Our staff members strive to keep the forums organized and clutter-free. All of our offerings are free-of-charge with all costs offset by banner advertising. Premium offerings are available to improve your experience.

User Menu

Secure Browsing & Transactions

eLightbars.org uses SSL to secure all traffic between our server and your browsing device. All browsing and transactions within are secured by an SSL Certificate with high-strength encryption.